MATERIAL SAFETY DATA SHEET
AIR COOLER CLEANER (CLEANER 620)
1. IDENTIFICATION OF THE PREPARATION AND THE COMPANY
PRODUCT NAME: Cleaner 620
APPLICATION: Air cooler cleaner
COMPANY IDENTIFICATON: Delaranrooz.Co
Address: No 217,Unit 16, St Kallhor,St Navab,St Azadi,Tehran/Iran
EMERGENCY TELEPHON NUMBER: +9821 66947449,66947491,66947522
2. COMPOSITION/ INFORMATION ON INGREDIENTS
CHEMICAL DESCRIPTION:
Butyl glycol detergents, hydrocarbon
HAZARDOUS INGREDIENTS:
CAS NO. EINECS NO. CHEMICAL NAME WT% SYMBOL R-PHRASES Mixture Mixture Butyl glycol
8-10 Xn 65
3. HAZARDS IDENTIFICATION
HUMAN HEALTH HAZARDS - ACUTE: INHALATION:
May cause imitation of mucous membranes. May cause headache and dizziness. Components of the
product may affect the nervous system.
SKIN CONTACT:
Can cause mild irritation.
EYE CONTACT:
Can cause mild irritation
INGESTION:
Harmful: may cause lung damage if swallowed. There may be irritation to the gastro - intestinal tract with nausea and vomiting. Can cause chemical pneumonia if aspirated into lungs following ingestion.
HUMAN HEALTH HAZARDS- CHRONIC:
Prolonged / frequent skin contact may cause dermatitis
ENVIRONMENTAL HAZARDS:
None known.
PHYSICAL AND CHEMICAL HAZARDS:
FLASH PHOINT NONE
4. FIRST-AID MEASURE
INHALATION:
Remove to fresh air , rest, treat symptomatically .obtain medical attention.
SKIN CONTACT :
Remove contaminated clothing. wash off affected area immediately with soap and plenty of water.
EYE CONTACT :
immediately gently irrigate with clean water for at least 15 minutes. move eyeball and keep eyelids wide open and apart whilst irrigating. obtain medical attention immediately
INGESTION :
Do not induce vomiting : contains petroleum distillates and / or aromatic solvents .
if conscious washout mouth and give one pint of water to drink . obtain medical attention.
ADDITIONAL INFORMATION:
If unconscious do not give anything by mouth , place in the recovery position, check breathing and pulse . if necessary give artificial respiration .
5. FIRE-FIGHTING MEASURES
EXTINGUISHING MEDIA :
Water spray, foam, dry powder , carbon dioxide.
UNSUITABLE EXTINGUISHING MEDIA:
Do not use water gets.
FIRE AND EXPLOSION HAZARD:
oxides of nitrogen, oxides of sulphur, oxides of carbon (under fire conditions)
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE FIGHTING:
In case of fire, wear a full face positive - pressure self contained breathing apparatus and protective suit. Water mist may be used to cool closed containers.
6. ACCIDENTAL RELEASE MEASURES
PERSONAL PRECAUTIONS :
Remove sources of ignition. Ensure adequate ventilation. Wear organic vapours respirator if ventilation is inadequate. Wear chemical resistant apron, chemical splash goggles, impervious gloves
and Wellington boots.
ENVIRONMENTAL PRECAUTIONS :
Do not allow to enter sewers or water courses. if spillage does enter sewers or water
courses, immediately inform the appropriate water authorities
METHODS FOR CLEANING UP:
Contain and absorb with sand or vermiculite and mix well. Collect up and remove to a safe place until disposal. Wash site of spillage thoroughly with water and detergent. Assistance can obtained from waste
disposal companies.
7. HANDLING AND STORAGE
HANDLING:
Avoid contact with skin and eyes. If clothing is contaminated, remove clothing and thoroughly wash the affected area. Launder contaminated clothing before reuse. Ensure adequate ventilation, No smoking. Avoid use of rubber. Spraying- spraying can lead to high solvent vapour concentrations. Wear organic vapours/mist respirator when spray cleaning large areas or if spray cleaning for an appreciable length of time.
STORAGCONDITIONS :
Keep container tightly closed in a cool, well- ventilated place. Connections must be grounded to avoid electrical charges. Store away from heat and sources of ignition. store separately fromoxidizers. Storage for more than two years is not recommended.
8. EXPOSIN CONTROL/PERSONAL PROTECTION
OCCUPATIONAL EXPOSURE LIMITS NATIONAL REGULATIONS UK
Total Hydrocarbons : recommendation 100 ppm (TWA)
ENGINEERING MEASURES
Local exhaust ventilation if necessary to control airborne levels below the exposure guidelines.
RESPIRATORY PROTECTION
Wear organic vapour respirator ventilation is inadequate.
HAND PROTECTION :
PVC gloves.
SKIN PROTECTION:
Not normally needed . Apron and boots (if skin contact is likely).
EYE PROTECTION :
chemical splash goggles.
HYGIENE RECOMMENDATIONS :
keep an eye wash fountain available
9. PHYSICAL AND CHEMICAL PROPERTIES
FORM: Liquid COLOUR: Brown
ODOUR: Aromatic
VALUE UNIT TEST METHO BOILING POINT: NE
MELTING POINT: NA
FLASH POINT: >64 ْC SET A (typically 72)
AUTOFLAMMABILITY: 520 ْ C
| EXPLOSION LIMITS: | lower 1.0% | |
| upper6.0 | ||
| VAPOUR PRESSURE 20ْC | 0.7 | mbar |
| RELATIVE DENSITY: | @20ْC 0.86- | 0. |
| SOLUBILITY IN WATER: | Emulsifies | |
| PH | NA | |
| OCTANOL/ WATER COEFFICIENT: | NE | |
| VISCOSITY | NE | |
| BULK DENSITY: | NE | |
| FREEZING POINT: | NE | |
| POUR POINT: | NE |
Abbreviation : NE= not evaluated, NA= not applicable, NR =not relevant
10. STABILITY AND REACTIVITY
STABILITY:
Stable under ambient conditions .
CONDITION TO AVOID:
Heat and sources of ignition including static discharges.
MATERIALS TO AVOID
Oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS:
Oxides of nitrogen oxides of sulphur oxides of carbon (under fire conditions).
11. TOXICOLOGICAL INFORMATION
ACUTE TOXICITY DATA: ACUTE LETHALITY VALUES: No data available.
PRIMARY (DRAIZE TEST) SKIN/EYE
No data available.
SENSITIZATION:
No data available.
CHRONIC TOXICITY DATA:
No data available.
13. DISPOSALCONSIDERATION
Via authorized contractor.
NATIONAL REGULATIONS UK
Complete incineration. In accordance with the Environmental
Protection (Duty of care) Regulations 1991.
14. TRANSPORT INFORMATION
Class: Not regulated
15. REGULATORY INFORMATION
EC CLASSIFICATION:
HAZARD SYMBOL: Xn, HARMFUL
Xn, HARMFUL
Contains: BUTYL GLYCOL
RISK PHRASES:
R65 HARMFUL: May cause lung damage if swallowed.
SAFETY PHRASES:
S16 keep away from sources of ignition -No smoking. S24/25 Avoid Contact with skin and eyes. S23
do not breathe vapours. S37/ 39 Wear Suitable gloves and eye/ face protection. S62 if swallowed, do not induce Vomiting: seek medical advice immediately and show this container or label...
NATIONAL REGULATIONS UK
COSHH regulations apply. A precaution card is available and should
Be displayed wherever this product is used and stored (REF.ASP).
16. OTHER INFORMATION
